Home ATV Florida Forum ATV Florida Where to Ride? ATV Florida Links Advertise


Welcome, Guest. Please login or register.
Did you miss your activation email?

Login with username, password and session length
 
   Home   Help Search Calendar Login Register  
Pages: [1]   Go Down
  Print  
Author Topic: 2 stroke help!!  (Read 1733 times)
Dustin_89
Junior Member
**
Offline Offline

Location: Jacksonville FL

Posts: 41



View Profile

Ignore
« on: March 15, 2007, 09:31:57 PM »

Ok i took the head and jug off a motor of mine. its a 2 stroke. came off a honda cr125

Is there supposed to be gas under the piston? it dont seem right to be gas. i drained all the anti fezze..
if someoen needs a pic ill go take one..its in the arena where the crank shaft is? someone tell me is ther supposed to be gas down there?
Logged
sykolincoln
Supreme Member
*****
Offline Offline

Location: SOUTH GEORGIA BABY!!!

Posts: 663


save money on tires! ride a trike!


View Profile WWW

Ignore
« Reply #1 on: March 15, 2007, 09:54:40 PM »

well it is suposed to be wet under the piston, but do you have like a large amount of gas in the lower end?? then you may have some serious worn out rings or some other probs than, possibly even a crack somewhere in the piston.
Logged

3 wheelers are like parapalegic girls....you know you want to ride it!

www.3wheelerworldforums.com

www.sponsorhouse.com/Members/SOUTHGACUSTOMS
Yamahonda41
Senior Member
****
Offline Offline

Location: St. Pete

Posts: 292


Born to ride!


View Profile

Ignore
« Reply #2 on: May 23, 2007, 10:30:01 PM »

Just ran across your post.  Yes there would be gas under there. I had mine apart about 3 years ago so it's kind of fuzzy now but here goes.  The piston goes up creating a vacuum underneath that pulls the fuel/air misture in through the reed valves.  When the piston comes back down it forces the mixture up through the intake port into the combustion chamber. 

A common problem with the older CR125 2 stroke engine is the main bearing coming out of the race.  This will then allow crankcase oil to be pulled in with the fuel/air mixture.  Really smokes and a lot of oil goes into the exhaust pipe. There is no question if this has happened.

Logged

2004 Kawasaki VForce 700
2004 Honda 300EX
2001 Honda 300EX FMF Pipe, Holeshots
2000 Yamaha Warrior Maxxis Razr's
1989 Honda CR125 - Pro Circuit pipe
TRX450R_Racer
Retired Racer
Supreme Member
*****
Offline Offline

Location: West Palm Beach

Posts: 4171


**** Frank **** **FF&J Racing**


View Profile

Ignore
« Reply #3 on: May 24, 2007, 10:37:11 AM »

If the lower end is full of fuel your needle and seat isn't seating properly. You have a constant flow of fuel coming out of the carb into the cylinder. The way it works is when the bowl of the carb is full the float raises up and pushes a rubber needle into the hole where the fuel is coming from. If there is dirt or something that can stop it from sealing fuel will comtinue to fill the cylinder. It will leak by trhe rings beacuse they only seal under a load, not whaen sitting still. Your ring are probably OK. You need to clean out the carb.
Logged

Member of South East Florida Trail Riders

Life's to short, wear a helmet.
Dress for the crash, not for the ride.
Ripped off by Brandon George.
dodgefsu
Junior Member
**
Offline Offline

Posts: 72


View Profile

Ignore
« Reply #4 on: June 01, 2007, 03:37:41 PM »

fuel will leak into the air filter if the float in the carb is not working
Logged
KB
Guest

« Reply #5 on: June 01, 2007, 04:19:05 PM »

If the lower end is full of fuel your needle and seat isn't seating properly. You have a constant flow of fuel coming out of the carb into the cylinder. The way it works is when the bowl of the carb is full the float raises up and pushes a rubber needle into the hole where the fuel is coming from. If there is dirt or something that can stop it from sealing fuel will comtinue to fill the cylinder. It will leak by trhe rings beacuse they only seal under a load, not whaen sitting still. Your ring are probably OK. You need to clean out the carb.

This man know's his sh!t, i bought a 250R from him a few months ago, good people.
Logged
Pages: [1]   Go Up
  Print  
 
Jump to:  

Other Florida sites of interest: www.PinballShark.com

Powered by MySQL Powered by PHP Powered by SMF 1.1.21 | SMF © 2015, Simple Machines Valid XHTML 1.0! Valid CSS!